Open access peer-reviewed chapter - ONLINE FIRST

Durable Woods and Antifungal Activity of Their Essential Oils: Case of Tetraclinis articulata (Vahl) Masters and Cedrus atlantica Manetti

By Abdelwahed Fidah, Mohamed Rahouti, Bousselham Kabouchi and Abderrahim Famiri

Submitted: November 27th 2018Reviewed: June 3rd 2019Published: September 16th 2019

DOI: 10.5772/intechopen.87214

Downloaded: 60

Abstract

Cedrus atlantica Manetti and Tetraclinis articulata (Vahl) Masters are a resinous species originated from North Africa and well known for their durable and noble timbers. This work was conducted to assess the relationship between natural durability of their woods, assessed in previous works by European standards NF EN 350 and CEN/TS 15083-1, and the bioactivity of essential oils extracted from these woods by hydrodistillation and analyzed by GC-FID and GC-MS. Bioassay of sawdust essential oils, conducted by direct contact technique on agar medium on four wood-decaying fungi strains, revealed strong antifungal inhibition especially by T. articulata root burl oil due to its richness in phenols. Natural durability classes of T. articulata and C. atlantica woods were then positively correlated with antifungal activity levels of their oils.

Keywords

  • Cedrus atlantica
  • Tetraclinis articulata
  • wood durability
  • essential oils
  • wood-decaying fungi

1. Introduction

Tetraclinis articulata (Vahl) Masters (Cupressaceae) and Cedrus atlantica Manetti (Pinaceae) are threatened species [1] endemic to the western Mediterranean areas [2]. Moroccan T. articulata and C. atlantica populations occupy an area of about 500,000 and 130,000 ha, respectively, and satisfy many socioeconomic needs of the human riparian populations for various products. But in the last decades, forests of T. articulata were exposed to a significant degradation due to a strong demand by the craft sector for timbers [2, 3]. Even if C. atlantica forest provides approximately annually 90,000 m3 of softwood logs intended for sawing and veneer, they also suffer the same fate [4]. Both species are famous for their durable and noble timbers. T. articulata root burl provides good quality woody material (hard, homogeneous, and fine grained) with remarkable flecks and an aesthetic aspect very appreciated in cabinetry and marquetry uses [3]. Laboratory tests showed that T. articulata trunk wood and its root burl are durable against wood-decaying fungi [5, 6] as well as C. atlantica heartwood [6, 7, 8].

A lot of waste as slabs and sawdust results from wood processing of those species timbers. However, only sawdust accounts for about 8% of C. atlantica sawn timber that contains appreciable amounts of extractives [9, 10, 11, 12]. Many recent works highlighted that essential oils (EOs) extracted from T. articulata and C. atlantica woods possess numerous biocidal activities [12, 13, 14, 15]. Nevertheless, only few attempts to investigate the capability of EOs to protect woods against fungi decay have been previously undertaken [16, 17, 18]. The relationship between natural durability of T. articulata and C. atlantica woods and the bioactivity of their EOs was not yet established. Therefore, the present study is devoted to investigate this relationship.

2. Material and methods

2.1 Material used for EOs extraction and chemical analysis

Trunk wood and root burl samples of T. articulata were collected from sweepings of craft processing workshops in Khemisset Region (central plate of Morocco), while samples of C. atlantica sawdust were collected from wood sawmill in the region of Azrou (Middle Atlas Mountains of Morocco). Sawdust was then sieved into particles of 1 mm size and triplicate samples of 250 g were subjected to hydrodistillation for 4 hours to obtain pure essential oils (EOs).

The chemical analysis and component identification of EOs were performed by gas chromatography (GC-FID) and by gas chromatography coupled with a mass spectroscopy (GC-MS). The identification of EO components was achieved by comparison of their retention indices (RI) relative to (C8-C22) n-alkanes with those of known compounds, and by comparison of similar mass spectra using Wiley/NBS mass spectral library of the GC-MS data system and other published mass spectra [19]. The percentage compositions of samples were calculated according to the area of the chromatographic peaks using the total ion current.

2.2 Material used for bioassay

Bioactivity of EOs extracted from T. articulata and C. atlantica woods was assessed in bioassay against the following wood-decaying basidiomycetes fungi: Gloeophyllum trabeum (BAM Ebw.109 strain), Oligoporus placenta (FPRL. 280 strain), Coniophora puteana (BAM Ebw. 15 strain), and Trametes versicolor (CTB 863 A strain). Fungi strains originated from the mycological collection of the Laboratory of Botany, Mycology and Environment, Faculty of Sciences in Rabat, Morocco.

2.3 Experimental

Bioassays of EOs were performed by direct contact of fungi strains on agar medium according to the method reported by Remmal et al. [20]. Oils were first diluted in a sterile solution of tap water-agar at 0.2% in order to obtain a homogeneous mixture, then distributed in test tubes containing 13.5 ml of sterilized malt-agar medium (20 g/l malt extract and 15 g/l agar), and kept at 45°C in a water bath. To obtain the final oil concentrations in the culture medium ranging from 1/250 to 1/5000 v/v, aseptic volumes of 1.5 ml of different dilutions were then added to those tubes before pouring EO-medium mixtures into Petri dishes. Additional control dishes containing only 13.5 ml of culture medium and agar solution at 0.2% (SA) alone were also prepared. Inoculation of Petri dishes was made by two 0.5 cm2 fragments of 10 days old fungal culture in malt-agar. For each treatment, three repetitions were prepared and incubated in the dark for 7 days at 22°C. At the end of each bioassay, minimal inhibitory concentration (MIC) [21] was determined for each fungus.

2.4 Results and discussion

According to the bioassay conducted on oils extracted from T. articulata and C. atlantica woods, a significant inhibitory effect on the four tested wood-decaying fungi was observed (Table 1) with different levels of inhibition. T. articulata root burl wood EOs showed, however, a strong inhibitory action against those fungi strains with oil dilutions over 1/4000 v/v. G. trabeum fungus was the most sensitive to the inhibitory effect of this essential oil since it was inhibited by concentrations between 1/5000 for T. articulata root burl oil and 1/1000 v/v for Atlas cedar oil. O. placenta was the most resistant strain since its growth inhibition was not reached until 1/400 concentrations for C. atlantica oil and 1/800 for T. articulata trunk wood oil (Table 1).

Essential oils fungal strainsThuya trunk woodThuya root burlAtlas cedar wood
Specific MICT. versicolor1/10001/40001/800
C. puteana1/10001/40001/400
G. trabeum1/12001/50001/1000
O. placenta1/8001/50001/400
Global MIC1/8001/40001/400

Table 1.

Minimal inhibitory concentrations (MIC) (v/v) determined for essential oils of thuya and Atlas cedar woods by bioassay conducted on malt-agar medium on wood-decaying fungi.

Previous studies by our team [5, 8] showed that T. articulata and C. atlantica woods were classified as very durable to durable (DC 1 and 2) and means of mass loss of test specimens was below 5.20% compared to those of Scot pine wood (control) (40.70%). According to their durability indexes (X) determined by NF EN 350-1 and CEN/TS 15083-1 standards [22, 23] and the biological risks defined by EN 335-2 standard [24], natural durability levels of those woods against wood-decaying fungi allow them to access high-risk classes of biological attacks 4 and 5 for an end-use without preservative treatment regarding decay fungi [25, 26]. Compared to similar studies on Moroccan coniferous woods (Figure 1), the natural durability of native Atlas cedar wood is similar to that of C. atlantica heartwood (DC 1 and 2) originated from a south Italian plantation [7], whereas Pinus halepensis and P. pinaster woods were considered as less durable (DC 4) [6, 27]. Generally, pine woods contain less active extractives than those of Cupressaceae. Adamopoulos et al. [28] reported that the weakness of natural durability of both heartwood and sapwood of Pinus leucodermis is related to low presence of bioactive extractives that can inhibit the brown-rot fungus, Coniophora puteana.

Figure 1.

Natural durability of studied woods against wood-decaying fungi.

In addition, other works by our team [8, 29] revealed that EOs of C. atlantica wood is dominated by ketones (52.05%) and alcohols (26.58%), while those of thuya are dominated by alcohols (about 55–78%) and sesquiterpenes (13–22%) (Table 2). Major components of C. atlantica oil are, respectively, E-γ-atlantone, E-α-atlantone, 5-isocedranol, 9-iso-thujopsanone, cedranone, Z-α-atlantone, cedroxyde, and 14-hydroxy-δ-cadinene [8] (Table 3).

Chemical groupThuya trunk woodThuya root burlAtlas cedar wood
Alcohols54.8078.5026.60
Esters5.70
Ketones1.400.3052.00
Oxydes0.900.603.40
Terpenes31.2014.108.00
Others1.751.15
Global90.0494.6595.69

Table 2.

Chemical groups (in%) identified, by GC-MS, in essential oils of Tetraclinis articulata and Cedrus atlantica woods.

Chemical groupComponentKITTWTRBACW
AlcoholsThymol12908.2039.80
3-Tert-butyl-4-methoxyphenol149116.5024.70
Turmerol15783.45
Cedrol159614.806.351.90
α-Acorenol16334.201.10
β-Acorenol16374.151.30
Himachalol16470.302.45
5-Isocedranol166911.70
β-Santalol17412.00
E-Z-Farnesol17421.10
Totarol23142.601.50
EstersHexyl isobutyrate11501.38
Benzyl benzoate17621.16
Z-β-Santalol acetate18231.15
Z-Ternine18381.25
KetonesCamphor11430.111.28
Cedranone16204.13
9-Iso-thujopsanone16374.45
Deodarone (Dihydro-2,2,6-trimethyl-6-(4-methyl-3-cyclohexen-1-yl)-2H-pyran-3(4H)-one)16941.07
E γ-Atlantone170119.73
Z α-Atlantone17134.02
E α-Atlantone17730.7416.86
Oxidesitalicene oxide15380.910.59
Cedroxide17042.38
Terpenesα-Cedrene140917.597.77
β-Cedrene14344.001.80
α-Himachalene14471.07
Thujupsadiene14621.10
α-Acoradiene14642.33
β-Acoradiene14652.26
β-Himachalene14991.250.79
α-Dehydro-ar-himachalene15111.13
γ-Cadinene15131.180.31
γ-Dehydro-ar-himachalene15291.57
14 Hydroxy-murolene17751.00
14 Hydroxy δ-cadinene17991.210.241.94

Table 3.

The main components (in%) identified, by GC-MS, in essential oils of Tetraclinis articulata and Cedrus atlantica woods.

KI, Kovàts Index; TTW, Thuya Trunk Wood; TRB, Thuya Root Burl; ACW, Atlas Cedar Wood.

EOs of T. articulata woods are rich in thymol, 3-tert-butyl-4-methoxyphenol, cedrol, and α-cedrene (Table 3). The oil of T. articulata trunk wood contains phenols such as α- and β-acorenol, cedrol, and totarol, along with terpenes as α-cedrene that can protect this wood from fungi decay. The strong inhibitory effect of T. articulata root burl oil is probably due to its oxygenated fraction rich in phenols as thymol, 3-tert-butyl-4-methoxyphenol, and cedrol. A previous work already highlighted this significant antibacterial activity at low concentrations [30]. Abundance of tropolones and phenols in Cupressaceae woods may explain their high natural durability grades against wood-decaying fungi as reported by Haluk and Roussel [16] and by more recent works [13, 30, 31]. Early investigations found that thujaplicines (tropolones) of Thuja plicata possesses strong inhibitory effect against the wood blue stain fungi and many wood-decaying fungi [32].

Natural durability of C. atlantica wood can be correlated to bioactivity of its oils essentially rich in sesquiterpene ketones as atlantones [9, 14]. In the literature, African padauk (Pterocarpus soyauxii) medium-heavy heartwood manifests a remarkable decay resistance attributed to its specific extractive compounds [33]. Moreover, extractive compounds obtained from black locust heartwood were able to increase the native durability of European beech against wood-decaying fungi from class 5 (not durable) to class 3 (moderately durable) [34].

The strong antifungal activity of T. articulata root burl wood EOs is probably related to their alcohol fraction, rich in thymol and 3-tert-butyl-4-methoxyphenol, which confer them this significant bioactivity. The combined action of two phenolic compounds, such as thymol and carvacrol, was previously reported [17, 35]. Action of phenolic compounds on fungi is primarily based on the inhibition of fungal enzymes containing SH group in their active site [36, 37]. The antifungal activity of the EOs of C. atlantica wood can be correlated to its sesquiterpene ketones, which are mainly atlantones (about 40.61%). Bioassays conducted with pure α-atlantones extracted from Decalepis hamiltonii revealed great inhibitory activity against pests and molds [38]. In our study, alcohols present in C. atlantica oil in significant amount (more than 26%), such as isocedranol, tumerol, himachalol, and cedrol, may also be involved in the inhibitory effect of this oil. Other compounds such as cadinenes (monoterpene hydrocarbon) could also have a great antimicrobial property [39]. However, synergistic action of two or more components of essential oils extracted from thuya and Atlas cedar woods can also be involved in the observed bioactivity reported in our study.

Antifungal activity of several thyme species oils was recently tested successfully against wood-decaying fungi especially those of Thymus bleicherianus [17]. Furthermore, EOs of T. articulata root burl showed an antibacterial activity two to six times greater compared to that of reference antibiotic and were more effective on Staphylococcus aureus (Gram+) and Escherichia coli (Gram) with significant bacteriostatic and bactericidal effects [40]. Regarding inhibition mechanisms of active compounds of EOs, it was reported that volatile alcohols can act on both lytic and synthetic enzyme pathways and growth inhibition consequently occurred after breaking off natural extension hyphae of fungi [41, 42].

Active compounds contained in oils of T. articulata and C. atlantica woods, which were successfully tested against wood-decaying fungi, may protect and ensure good natural durability levels for these woods ranging from very durable (DC1) to durable (DC2) classes.

Findings of this study could allow us to consider recovering wastes from T. articulata and C. atlantica wood processing for the extraction of bioactive oils and use them as biocide especially in preservative treatment of less-durable woods such as those of pines. Also, these results are in favor of more protection for these threatened species and for the rehabilitation in their natural environment. Natural compounds of T. articulata and C. atlantica oils can then replace the use of current petrochemical compounds that are becoming more and more criticized for their harmful effect on human health and the environment.

3. Conclusion

The present study has clarified the relationship between the natural durability of T. articulata and C. atlantica woods and the antifungal activity of their EOs. According to the bioassay conducted on those oils, a significant inhibitory activity was obtained on the four wood-rotting fungi tested, mainly for oils extracted from T. articulata root burl. Stronger inhibitory effect was then reached by dilutions over 1/5000 v/v for this oil rich in phenols. The durability classes of T. articulata and C. atlantica woods positively correlated with bioactivity of their oils against the three wood-decaying fungi specified by the CEN/TS 15083-1 standard. Active EOs extracted from wastes of these woods can be valorized as wood-preservative treatment.

Acknowledgments

This project is supported by Forest Research Center in Rabat (High Commission for Water and Forests and Fight against Desertification) in collaboration with Faculty of Sciences in Rabat (Mohammed V University), Morocco.

Download

chapter PDF

© 2019 The Author(s). Licensee IntechOpen. This chapter is distributed under the terms of the Creative Commons Attribution 3.0 License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

How to cite and reference

Link to this chapter Copy to clipboard

Cite this chapter Copy to clipboard

Abdelwahed Fidah, Mohamed Rahouti, Bousselham Kabouchi and Abderrahim Famiri (September 16th 2019). Durable Woods and Antifungal Activity of Their Essential Oils: Case of <em>Tetraclinis articulata</em> (Vahl) Masters and <em>Cedrus atlantica</em> Manetti [Online First], IntechOpen, DOI: 10.5772/intechopen.87214. Available from:

chapter statistics

60total chapter downloads

More statistics for editors and authors

Login to your personal dashboard for more detailed statistics on your publications.

Access personal reporting

We are IntechOpen, the world's leading publisher of Open Access books. Built by scientists, for scientists. Our readership spans scientists, professors, researchers, librarians, and students, as well as business professionals. We share our knowledge and peer-reveiwed research papers with libraries, scientific and engineering societies, and also work with corporate R&D departments and government entities.

More About Us